No. 07100 - Woodcomp
Transkript
No. 07100 - Woodcomp
SERVICE BUTLETIN No. 07100 V-218, ser. PROPELLER PREVENTIVE INSPECTION Thisservice Bulletin is issued in line with the orocedures subiectto Type certificate holder: Type / Model: AIC5 KNEMEN Type certificate number EASA AP2 50 Autho rizatio n. V-218 series PROPELLER Fixed pitch wooden aircraft propeller EASA,P,177 Related documents EVEKToR, spol. s r.o.: Mandatory Bulletin No. sw13-066a SR R1, issued 10.12 2015 Replaces Manufacturer Applies to Woodcomp Propellers s.r.o. All V-218 series propellers used on EASA cenified aircraft (e.8.: L 13 SW, L 13 SE Vivat motor gliders). lf the inspection of propeller requested below has already been performed according to t\4andatory Bulletin No. SW13-066a SR R1, issued by Evektor, it need not be replacedl Reason There was one incident with positive identification of counterfeit V-218 series propeller being used on Ll3SEVivat motorglider. Due to suspected use offurther counterfeit propellers, the holder of V 218 type certificate issues this Order ro inspect all affected propellers. Effective date 2!.01.2016 Work procedure To maintain continLrous airworthiness, it is necessary to perform: Physical inspection of installed propeller, using identification signs listed in Annex 1 to this Service Bulletin. The propeller need not be removed from the A,/c for - inspection. Measure Administrative check of propeller accompanyinB documentation. Provided that the inspection found compliance with the description of identification signs listed in Annex 1to this Service Bulletin, authorized person will record the following into the Propeller logbookr "Verification ofV-218 propeller, S/N ......., has been performed according to service Bulletin No. 07/00, and no discrepancies have been found". lfthe propeller does not meet the description of identification signs listed in Annex 1 to this Service Bultetin, it must be removed from A/C immediately and this issue must be reported to holder ofV-218 type certificate using form F 4-02_l "Unairworthy condition report" - Annex 2. lf in doubt when trying to identify the propeller, please contact woodcomp Propellers s r.o, Phoner +420 283 971309 Fax: +420 283 97o 246 E-mail: info@ivoodcomp cz Work to be performed By service organization authorized by Alei KREMEN, vodolsktt Phone: +420 2aj 4 the manufacturer Dotinek;250 Toodoleno vado, c2ech Republic 977 3A9i Mabil: +420 6A2 323 304: Fox: +420 28i e noil : [email protected]. www.woodconp.cz 970 286 SERVICE BUTLETIN No. 07100 schedule To be performed during the next 50hour/yearly inspection Costs borne by Operator Paget 2/2 Material necessary Remarks Manager Accountable: Quality Manager: Rev. 00 Name: AIei Kiem Name: Vitclav IVatouSek Date: Sign: 27.07.2076 Sign: //-;6 4 Dolinek; 250 70 odoleno vado, czech Republic 971 309: Mobil: +420 642 323 3O4i Fax: +424 2$ 974 286 Ale! KREMEN, vadolskd Phane: +42A 2$ e't"ott : skrksry!@rsz!9Lla www wood.an1 cz SERVICE Annex 1- BUttETIN No. 07100 V-218 PROPELLER IDENTIFICATION SIGNS This annex lists identification signs ofV-218 series propellers (TC EASA.P,175) depending on manufacturer of specific piece. 1. Manufacturer: AERoN. podnik 0V Svazarmu Brno Propeller model: v-278; v-278A srgrogej 6 mm stamped digits and/or letters at the side of propeller head: - Type signage: V 218, or V 218 A - Three- or four-digit serial number - Triangle logo ofAERON company. See example Fig. t ,,0 , Mfg lobel: None Leoding edge.Stainless steel segments, 0.4mm thick Usuol colour finish: Iransparent lacquer on blades; black/white strips or yellow paint at blade tips Accompanying documenti Product quality and completeness certificate and Propeller log. 2. Manufacturer: VzLo, a.s. Propeller model: V-2L88 (SN in range 01. to 39) Slgnoge; Block serial number written using colour pencil inside propeller hub Mfg lobet: vzLt adhesive mfg label at hub side - see Fig. 2 Fig.2 Compony tdbel: vzLt logo label at both blades Leading edge: Heffed poured resin Usuol colour finish: W hite blades, yellow tips, black matte rear side Accompdnying documentj Propeller log and EASA Form 1 issued by VZLU, a.s. PaEeTl2 SERVICE BUTLETIN No, O7IOO Annex I - V-218 PROPELLER IDENTIFICATION SIGNS 3. Manufacturer: Alei Kiemen or Woodcomp Propellers s.r.o. Propeller model: V-2!88 Sigroger 8mm stamped digits and/or letters at the side of propeller head: - Type signage (V-218B), - Complete serial number RR-MM-xx. Mfg Io bel Adhesive mfg label at hub side - depending on manufacturer: Propeller serial numbers 09-08-001to 13-12'050 bear Alei Kfemen label - see Fig.3 Propeller serial numbers 13-12-051to 15-05-064 bear Woodcomp Propellers s.r.o. label - see Fie. 4 : - Fig.4 Fig.3 b*T_tPllq{il-'"" wooDcoMp lz*r n+uorc ", -:ii zrc.oors r+s.ooaz rrr.wo.lcomp-cz )odcomD ProDellers TCoS s/N Compqny lobel: woodcomp logo label at both blades Leoding edgei Raku-fool poured resin IJsuol colour finish:Iransparent lacquer on blades, yellow tips, black matte rear side Accompdnying documerf. Propeller log and EASA Form 1 issued by Alei Kfemen or Woodcomp Propellers s.r.o. ADDITIONAL NOTESI 1 Alternatives different from usual colour finish listed above are possible. 2 Propellers have time-defined lifespan, 20 years since manufaduring date, i.e. all propellers older than 20 years (on starting inspection) are not airworthy anymore. 3. Unless the propeller has related accompanying documentation, it must airworthy. Inspection of such propeller and its release into WoodcomD ProDellers s.r.o. Paee2/2 be deemed not operation can only be made by HLASENIUDALOSTI Annex No. 2 ANAIRWOR'IH Y CONDI TI ON RE PORT Vrtule tVp: TvDe of the PrcDellen H16ieni odeSlete na adresu: Repoft send to dddrcss: sB 07100 Ab5 KNEMEN vodolski 4, Dolinel( 250 70 Odolena Voda czech Republic telefon:+420 602 323 304 +42O 283 97A 2a6 fax: e-mail : info @woodco !!p.ez 76d6me, aby nitm byly hleienyvsouladu s ustanovenim L8/A 212.2 a 2.12 3 tyto udiilosti: po:iiry zpisoben6 poruchou, ziivadou nebo nespr6vnou flnnosta poruchy, zi4vady nebo nesp16vn6 ainnost vrtule, kterd zp0sobi poikozeni motoru, piilehl6 konstrukce letadla nebo jeho vistroje a) b) c) norucha konstrukce vrtule za letu Ka:d€ hl6seni poiadovan6 ustanovenimi2.12 pfedpisu L8/A musibvt provedeno do 72 hodin a musiobsahovat viecnny d6le uveden6 dosrupn6 a pouikeln6 informacel We dskthatwe be reported in occordance with the a) L8/ A regulatrcn, potogtophs 212.2 ond 2.12.3 oJ the Jollawing Jites, coused by the foilurc, defect ot nolfunction defect ot nolfunction ofthe propeller, which couses ddmoge ta the engine, odjocentaircrcft b) foilurc, structurc, or his equipnent c) structu ral foilu re ofthe prcpellet inflight Eoch report requiled by the L8 / A regulation nust be done within 72 hours ond must include alloJthe follawing nJornotion accessible ond usable: 3. ohLaSovatel: s. Datum pod6nizprd!ry: *12. Zjiltdno pii ,dr:b6 na z,kadnd l4-La/a al.2.12.4, uved\e bod/Fefer.Paro oznaien I vvrobku vyrd bEn6ho podle Tc/src ne bo souhlasu s pouiitim, kteri by piitinou nebo ve spoje ni s hldienim: The indicotion af the Uotluct which is produced in the complionce with |C/'TC rype apptovol which wos the couse at ih the cantudian whh the teoon: 1s. Typovd oznaaenivirobkul 16. Vircbn i aislo virobku: Product seidl Number: Nunber of houts/cvcle: F 4-02 1 1/2 Priloha e.2 HLASENi UDALOSTI UNAIRWORTHY C ONDITION RE PORT Annex No. 2 sB 07100 oznaaenisouadsticelku nebo sousta!'y, kterd jsou piiainou h16Seni: The indicotian of the conpanent ott systen whlch wds the couse oJ the report: 19, souadst celku nebosoustava; Patt unlt or Svstem: 22. Pov.l^. po-ucl'y zdvady iebo lespr,vle tinrosril Noturc ol foiture, defect or motfunctian 23 Odstrandn i zivady, pfijatd opatieni (Wpl6uji pouze dr:itel6 TCISTC, Souhlasu s pouiitim): DeJect Rectificotion, correcttve Actions (Conpletion by TC/STC Type Apptovolholderc only): 24 Adresiti:* 25 Poaet piiloh: 25 Consignees: uritel/Halderaf TClSTC * za\|Jtn|te/nark 4-02 1 natu re a nd pos itia n : UcL cAA cz Pii nedostatku mista pokraaujte na dtuh6 stran6 is necessory continuing onthe reverse page. lf it F Podprs a funkce: S ig 2/2